Lexus - GS 430 - Workshop Manual - 2016 - 2016

L-SB-0043-16 August 8, 2016 Rear View Mirror Discoloration Service Category Vehicle Interior Section Mirror (int) Market USA Applicability YEAR(S) MODEL(S) 2006 - 2009 GS300, GS350, GS430, GS450H, GS460 ADDITIONAL INFORMATION Introduction Some 2006 – 2009 model year GS vehicles may exhibit discoloration/distortion of the inner rear view mirror. A service part kit (mirror and frame) is available to address this condition. Figure 1. © 2016 Lexus, a division of Toyota Motor Sales, USA Page 1 of 7 L-SB-0043-16 August 8, 2016 Page 2 of 7 Rear View Mirror Discoloration Production Change Information This bulletin applies to vehicles produced BEFORE the Production Change Effective VINs shown below. MODEL VDS PRODUCTION CHANGE EFFECTIVE VIN CH96S JTHCH96S#60021076 BH96S JTHBH96S#65045858 CE96S JTHCE96S#90024011 BE96S JTHBE96S#90046626 GS 430 BN96S JTHBN96S#75017680 GS 450h BC96S JTHBC96S#95020111 GS 460 BL96S JTHBL96S#95003712 GS 300 GS 350 Warranty Information OP CODE DESCRIPTION TIME OFP T1 T2 N/A Not Applicable to Warranty – – – – Parts Information PART NUMBER PREVIOUS NEW 87810-30340 87801-30030 87810-30341 PART NAME QTY Mirror Sub-Assy, Inner RR View 1 Required Tools & Equipment SPECIAL SERVICE TOOLS (SST) PART NUMBER QTY Plastic Pry Tool Kit* 00002-06020-02 1 * Essential SST. NOTE Additional SSTs may be ordered by calling 1-800-933-8335. © 2016 Lexus, a division of Toyota Motor Sales, USA L-SB-0043-16 August 8, 2016 Page 3 of 7 Rear View Mirror Discoloration Repair Procedure 1. Remove the inner rear view mirror. Refer to the Technical Information System (TIS), applicable model and model year Repair Manual:  2006 GS 300: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Removal”  2007 / 2008 / 2009 GS 350: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Removal”  2006 / 2007 GS 430: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Removal”  2007 / 2008 / 2009 GS 450h: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Removal”  2008 / 2009 GS 460: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Removal” 2. Use a small trim removal tool to separate the 9 frame clips that hold the glass and “AUTO” button in place. NOTICE Remove ANY static before performing this procedure to avoid damaging circuit board components. Figure 2. 1 Frame 2 Frame Clip © 2016 Lexus, a division of Toyota Motor Sales, USA L-SB-0043-16 August 8, 2016 Rear View Mirror Discoloration Repair Procedure (Continued) 3. Remove the “AUTO” button and set aside. This part will be reused. Figure 3. 4. Discard old frame. 5. Remove and place distorted mirror glass face down on the work bench. Carefully pull away the circuit board from the mirror assembly to access the 2 wire connector on the back of the circuit board. Figure 4. 6. Disconnect the connector and discard distorted mirror glass. 1 Circuit Board 2 2 Wire Connector © 2016 Lexus, a division of Toyota Motor Sales, USA Page 4 of 7 L-SB-0043-16 August 8, 2016 Page 5 of 7 Rear View Mirror Discoloration Repair Procedure (Continued) 7. Place NEW mirror glass face down in NEW frame on work bench. Carefully pull circuit board away from the mirror assembly. Figure 5. 1 Mirror Assembly 3 2 NEW Frame with NEW Glass 2 Wire Connector 8. Reconnect the mirror glass connector on the back side of the circuit board. 9. Set the “AUTO” button into the NEW frame. © 2016 Lexus, a division of Toyota Motor Sales, USA L-SB-0043-16 August 8, 2016 Page 6 of 7 Rear View Mirror Discoloration Repair Procedure (Continued) 10. Line up the alignment pins on the NEW frame with the alignment holes in the circuit board. Figure 6. 1 Alignment Holes on Circuit Board 2 Circuit Board Mounted on Alignment Pins 11. Carefully snap in the 9 clips around the edge of the frame. 3 Alignment Pins Figure 7. © 2016 Lexus, a division of Toyota Motor Sales, USA L-SB-0043-16 August 8, 2016 Rear View Mirror Discoloration Repair Procedure (Continued) 12. Reinstall the inner rear view mirror. Refer to TIS, applicable model and model year Repair Manual:  2006 GS 300: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Installation”  2007 / 2008 / 2009 GS 350: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Installation”  2006 / 2007 GS 430: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Installation”  2007 / 2008 / 2009 GS 450h: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Installation”  2008 / 2009 GS 460: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Installation” 13. Calibrate compass. Refer to TIS, applicable model and model year Repair Manual.  2006 GS 300: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Calibration”  2007 / 2008 / 2009 GS 350: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Calibration”  2006 / 2007 GS 430: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Calibration”  2007 / 2008 / 2009 GS 450h: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Calibration”  2008 / 2009 GS 460: Vehicle Interior – Mirror – “Mirror: Inner Rear View Mirror: Calibration” 14. Confirm inner rear view mirror functions properly. © 2016 Lexus, a division of Toyota Motor Sales, USA Page 7 of 7